harley drain plug torque

They also come with the H-D sealant already applied. For a better experience, please enable JavaScript in your browser before proceeding. it is pretty involved but ive got good mechanical skills and am somewhat patient lol. 2006 Harley Davidson Touring Motorcycle Service Manual for: 2006 FLHX Street Glide, 2006 FLHT Electra Glide Standard, 2006 FLHTC Electra Glide Classic, 2006 FLHTCU Electra Glide Ultra Classic, 2006 FLTR Road 2006 Glide, FLTRI Road Glide. Place a few rags underneath the filter to catch any drips. Next, take the bike for a short ride to bring the engine to operating temperature. Slide your drain pan in place, then use the 5/8-inch socket and socket wrench to loosen the drain plug. Remember to check the oil while its hot and the bike is on the kickstand. . JMHO though. We have briefly discussed Harley Davidson torque specifications for only a few components and models. When component part replacement is necessary, use the engine type and serial number to identify the correct part. This image may not be used by other entities without the express written consent of wikiHow, Inc.
\n<\/p>


\n<\/p><\/div>"}, {"smallUrl":"https:\/\/www.wikihow.com\/images\/thumb\/e\/e0\/Perform-an-Oil-Change-on-a-Harley-Davidson-Twin-Cam-Engine-Step-10.jpg\/v4-460px-Perform-an-Oil-Change-on-a-Harley-Davidson-Twin-Cam-Engine-Step-10.jpg","bigUrl":"\/images\/thumb\/e\/e0\/Perform-an-Oil-Change-on-a-Harley-Davidson-Twin-Cam-Engine-Step-10.jpg\/aid8933928-v4-728px-Perform-an-Oil-Change-on-a-Harley-Davidson-Twin-Cam-Engine-Step-10.jpg","smallWidth":460,"smallHeight":345,"bigWidth":728,"bigHeight":546,"licensing":"

\u00a9 2023 wikiHow, Inc. All rights reserved. Also, inspect this O-ring here (1:00) It's not a bad idea to replace that. Inspect the drain plugs. wikiHow, Inc. is the copyright holder of this image under U.S. and international copyright laws. When you purchase through links on our site, we may earn an affiliate commission, which supports our community. wikiHow, Inc. is the copyright holder of this image under U.S. and international copyright laws. First give everything a good wipe down (oil filter opening, oil drain plug opening). They reflect the tough,, Read More A Complete Guideline On Harley Davidson Engine Size ChartContinue, Harley Davidson Switchback is known for its smaller and lightweight profile with an economical riding facility. wikiHow, Inc. is the copyright holder of this image under U.S. and international copyright laws. Don't want to have to prematurely, either! Shaft fit in bushing (loose) - 0.0005-0.0020 0.013-0.051End clearance - 0.003-0.013 0.08-0.033Bushing fit in rocker arm (tight) - 0.002-0.004 0.051-0.102Filtration - 10 micron media, filtered between pump and engin. Want To Buy Motorcycles/Parts/Accessories, Trades & Freebies (See Subforums for specific models), The Queens Of The Road (For Women Bikers), Support for The Troops and their Families, Do Not Sell or Share My Personal Information. If there is excessive metal on it, check the primary chain and clutch plates. The plug does not require a separate gasket. So, our oil has slowed to a drip. wikiHow, Inc. is the copyright holder of this image under U.S. and international copyright laws. I can't send you a picture but according to the drawing, the oil drain plug is in the bottom of the transmission oil pan. Your email address will not be published. This image may not be used by other entities without the express written consent of wikiHow, Inc.
\n<\/p>


\n<\/p><\/div>"}. Discussion in 'Softail Models' started by BOWHIKER, Mar 17, 2010. "Very helpful. Actually the drawing shows two drain plugs, one on the bottom and one on the front fo the oil pan. JavaScript is disabled. Replace the drain plug until it is snug, then torque it in. Use it to try out great new products and services nationwide without paying full pricewine, food delivery, clothing and more. For starters, Harley-Davidson engines are built for power and performance. By using the lower number of range on lets say a 90-100 ftlbs. wikiHow, Inc. is the copyright holder of this image under U.S. and international copyright laws. The differences begin at the molecular level. Pay the money, if you own a softail the Harley dealers sometimes strip out the drain plug, not to say Harley dealers have great mechanics but they are ok for oil changes. Glider is 1000 percent right, I have found most man. too far (rotating parts?). Next, apply a thin film of oil to the gasket on the new filter. If you apply more than its required torque, the thread of the screw may become damaged. You can also slide the oil pan underneath to catch oil that drains from the filter. Visit the Home page to get the complete factory service manual for your 2001-2009 Touring motorcycle and get it delivered to your computer in just seconds! ). 2021 Ultra Limited - 2004 Softail Springer - 1993 Dyna Low Rider - 1983 FLHT. A forum community dedicated to Harley Davidson V-Rod Motorcycle owners and enthusiasts. Thus, the motorcycle gets its top speed for which it is known. Milwaukee 8 oil drain plug location. On Softail models, the oil reservoir is located under the seat. So we're all set to fill her up. To create this article, 9 people, some anonymous, worked to edit and improve it over time. Be sure to check your owners manual or the AMSOIL Product Guide for the correct primary oil capacity for your bike. There's a torque spec for every bolt on the bike. This image is not<\/b> licensed under the Creative Commons license applied to text content and some other images posted to the wikiHow website. I like to be a good boy and follow the torque specs in the manual, etc.. As always, if you like what you see here, please subscribe to us. This article has been viewed 81,557 times. How to Replace Twin Cam Drive Belt For complete specifications for your year and model Touring motorcycle download the correct manual for yourbike from the DOWNLOAD CENTER. Which Automatic Transmission Fluid Do I Need? Keeping your Harley mechanically fit is no mystery, and all the required Harley Davidson Sportster How to Replace Clutch MF, 7am7PM Central James Gasket Harley Davidson 11105 - Drain Plug/Oil Pump Cap O-Ring Transmission | eBay People who viewed this item also viewed James Gasket Oil Screen Pump O-Ring - 25 Pack | 11105 $16.06 Free shipping James Gasket Drain Plug/Oil Pump Cap O-Ring - Oversize - 25 Pack | 11105-X Sponsored $15.58 Free shipping I have tried with pipe sealant applied and also w/ teflon tape. Order one when you order your oil and filter because you put this back in and if that O-ring leaks, you'll have to take all that fresh oil back out just to replace this little ring. This image may not be used by other entities without the express written consent of wikiHow, Inc.
\n<\/p>


\n<\/p><\/div>"}, {"smallUrl":"https:\/\/www.wikihow.com\/images\/thumb\/0\/08\/Perform-an-Oil-Change-on-a-Harley-Davidson-Twin-Cam-Engine-Step-6.jpg\/v4-460px-Perform-an-Oil-Change-on-a-Harley-Davidson-Twin-Cam-Engine-Step-6.jpg","bigUrl":"\/images\/thumb\/0\/08\/Perform-an-Oil-Change-on-a-Harley-Davidson-Twin-Cam-Engine-Step-6.jpg\/aid8933928-v4-728px-Perform-an-Oil-Change-on-a-Harley-Davidson-Twin-Cam-Engine-Step-6.jpg","smallWidth":460,"smallHeight":345,"bigWidth":728,"bigHeight":546,"licensing":"

\u00a9 2023 wikiHow, Inc. All rights reserved. thanks:thanks. This image may not be used by other entities without the express written consent of wikiHow, Inc.
\n<\/p>


\n<\/p><\/div>"}, {"smallUrl":"https:\/\/www.wikihow.com\/images\/thumb\/6\/62\/Perform-an-Oil-Change-on-a-Harley-Davidson-Twin-Cam-Engine-Step-14.jpg\/v4-460px-Perform-an-Oil-Change-on-a-Harley-Davidson-Twin-Cam-Engine-Step-14.jpg","bigUrl":"\/images\/thumb\/6\/62\/Perform-an-Oil-Change-on-a-Harley-Davidson-Twin-Cam-Engine-Step-14.jpg\/aid8933928-v4-728px-Perform-an-Oil-Change-on-a-Harley-Davidson-Twin-Cam-Engine-Step-14.jpg","smallWidth":460,"smallHeight":345,"bigWidth":728,"bigHeight":546,"licensing":"

\u00a9 2023 wikiHow, Inc. All rights reserved. The end of the plug is magnetic and will pick up metal shavings as well as debris. Zero-Turn Mower Maintenance Best Practices. This image is not<\/b> licensed under the Creative Commons license applied to text content and some other images posted to the wikiHow website. I do my cars myself but didnt know about 3 different oil plugs on HD. Yet, it covers a massive space. Although you might know that synthetic oils outperform conventional oils, you might not understand why. The cylinders are numbered from front to rear; 1, 2 and refer to service manual on the firing order. dont have the cash for a book at this time. Which Automatic Transmission Fluid Do I Need? Once its topped-off, insert the dipstick and check the fluid level one more time. Spark plug size - 12 mm Spark plug type Harley-Davidson - 6R12 Spark plug gap - 0.038-0.043 in. Copyright 2023 AMSOIL INC. All Rights Reserved. Do not over tighten . This image is not<\/b> licensed under the Creative Commons license applied to text content and some other images posted to the wikiHow website. 71. Then get your wrench, fit it to the plug, note the angle the wrench handle is pointing, and then tighten by an extra 1/8th of a turn or 45 degrees (if you're using a new crush washer). called the guy back and told him i was bringing the bike up to get it fixed and he said i was miss quoted on the price. It is a custom-made plug with a low profile to fit just below the case. Finish removing it by hand and quickly move it into your oil pan. Like I was saying, used to be you had to check these on the kickstand, AKA the jiffy stand. Screw the filler plug into the transmission with a 3/8-inch Allen wrench. The smaller plug comes with an o-ring on it that is worthless. The Fora platform includes forum software by XenForo. I just snug it up. Use a ratchet and 5/8-inch socket to remove the drain plug. Nice to know the location of all the drains. Your torque wrench should be set at 84-108 inch-pounds of torque. When you dont know about Harley Davidson torque specifications, you wont be able to service or upgrade the motorcycle. micro string bikinis; immo off software free; sab summer intensive 2022; authelia nginx; the millennium wolves free full story . Use a T27 bit to remove the five Torx bolts from the derby cover. I know I can thread mine all the way into the casing if not careful. Unscrew the filler plug from the left side of the transmission, using a 3/8-inch Allen wrench. Modern Harley Davidson drive belts will often last the life of the bike, but if it has been damaged, it is better to bite Harley Davidson Dyna Glide Installing Forward Controls Tighten the drain plug until the drain plug will no longer turn without having to add excess turning force. Hence, we will briefly discuss the torque specifications and show you how to use them for particular Harley motorcycle models. I searched and most every response was Install a fumoto drain valve or Probably like 25-30 ft. lbs. Please register or login to enable Dark Mode. How to Install Screamin' Eagle Compensator . Thread the filter onto the engine until you feel the gasket draw snug. Clean the residual debris from the drain plug, install a new O-ring and thread it back into the engine. In addition to what has been said about torque specs. The pictures below will help you understand why I don't give torque specifications when asked. It is not common, but some oils can cause the clutch to slip, and would need to be changed again immediately. Use a long-tipped and narrow funnel to get the oil down into primary through the derby cover or inspection cover. Yet, they will need regular maintenance. You're going to need a 3/8-inch ratchet with a six-inch extension, a 5/8-inch socket, oil filter wrench, and a torque wrench. This article applies to the Harley Harley Davidson Touring General Information and Recommended Maintenance Schedule The only thing that counts in the end is power! That's all. Step 7 - Add new oil to your bike. The first service manual picture is of the final torque of the compensating sprocket bolt on a 2012 Street Glide with a 103cu engine. This image is not<\/b> licensed under the Creative Commons license applied to text content and some other images posted to the wikiHow website. someone answer me a question. how can the MoCo spec a torque setting of BETWEEN 14-21 ft lbs? This image may not be used by other entities without the express written consent of wikiHow, Inc.
\n<\/p>


\n<\/p><\/div>"}, {"smallUrl":"https:\/\/www.wikihow.com\/images\/thumb\/b\/b1\/Perform-an-Oil-Change-on-a-Harley-Davidson-Twin-Cam-Engine-Step-9.jpg\/v4-460px-Perform-an-Oil-Change-on-a-Harley-Davidson-Twin-Cam-Engine-Step-9.jpg","bigUrl":"\/images\/thumb\/b\/b1\/Perform-an-Oil-Change-on-a-Harley-Davidson-Twin-Cam-Engine-Step-9.jpg\/aid8933928-v4-728px-Perform-an-Oil-Change-on-a-Harley-Davidson-Twin-Cam-Engine-Step-9.jpg","smallWidth":460,"smallHeight":345,"bigWidth":728,"bigHeight":546,"licensing":"

\u00a9 2023 wikiHow, Inc. All rights reserved. Remove it the rest of the way by hand so it, Understanding Fluid Lubrication and Protection. So we've got to get the oil out of this bike. This image is not<\/b> licensed under the Creative Commons license applied to text content and some other images posted to the wikiHow website. The example used here is an 88 cubic feet (2.5m3) Softail. There is a proper torque value for the oil drain plug. Once the cover is back on, get the bike down and take it for a test ride. Hi all. wikiHow, Inc. is the copyright holder of this image under U.S. and international copyright laws. took it out and had to readjust the clutch,loosen the drive belt just a bit and adjust shift lever. wikiHow is where trusted research and expert knowledge come together. Note: The information below should not be used as a reference as this is only a sample of information typicaly found in a service manual. I believe the torque value is around 25 ft/lbs. This article applies to the Harley Davidson Touring Replacing Twin Cam Drive Belt so.you can torque a bolt to 14, or almost DOUBLE that to 21 lbs? JavaScript is disabled. Start the engine and run at varying speeds up to 2,500 RPM for three minutes. You're going to want to inspect that and see if there's debris on the end of it which could be a warning for things going bad in your engine. wikiHow marks an article as reader-approved once it receives enough positive feedback. Good to know capacities, "I followed the instructions. 2.) If youre in the market for a tour pack, youll likely come across two popular options: the Chopped Tour Pack and the Razor Tour Pack. Dont overdo it. Now that we've got our drain plug back in, we're going to hop over to the other side, get our filter off, get our new filter back on, and get some oil in this thing. Refer to your service manual for locations of serial stamp locations and for complete specifications of your year and model motorcycle. wikiHow is a wiki, similar to Wikipedia, which means that many of our articles are co-written by multiple authors. Also, riders admire this bike for its easy approachability and ability to ride comfortably through the city streets and occasional touring. By leek auctions store sales. Loosen it up to make sure we can draw some air through and it doesn't get a vacuum and leave oil in the system. We also found 79 foot-pounds of torque capacity for the 1340-cc. Its popularity is mainly because of the unique design, quality, and comfort, Read More The Harley Davidson Jacket: Is It WorthContinue, Harley Twin Cam and Evo engines have been among the top debating issues for Harley lovers in the past two decades. During a check of those bolts if it does not move then your good to go. This isn't Harley's spec. Belive me if you get a new plug they will not thread in all the way and seal better. When the primary has finished draining, you'll want to inspect the plug for any debris. My '04 RK manual says some mm measurment too. 144 Nm @ 3000 rpm is the torque value for the Harley Fat Boy 114. Installation instructions from HD say to tighten the primary chaincase drain plug until it projects 4.1 to 4.6mm out from the case. Discussion on V-Twin Harley Davidson motorcycles including Dyna, Electra Glide, Softail, Sportster, and more. The new Milwaukee-Eight takes four and a half quarts. vs Twin Cam: What Makes the Difference? Your primary chain oil should be replaced at every second or third oil change, but it is easy and cheap enough that you might consider changing it with every oil change. Before you begin, its For this demonstration, were using a 2014 Harley-Davidson Softail Fat Boy Lo with a 103-ci engine. We're going to start with the one that we pre-loaded our oil filter with and go from there. Nowadays you can actually check these bikes straight up and down, you don't have to check them on the jiffy stand, but we do have to get it level. 2007 Harley Davidson Touring Service Repair Manual & Electrical Diagnostics Manual For: (2007) FLHT Electra Glide Standard (2007), FLHR Road King (2007), FLHTC Electra Glide Classic (2007), FLHRS Road King Custom (2007), FLHTCU Ultra Classic Electra Glide (2007), FLHRC Road King Classic (2007), FLTR Road Glide (2007), FLHX Street Glide (2007).

And services nationwide without paying full pricewine, food delivery, clothing and more insert dipstick. As well as debris dont know about Harley Davidson torque specifications for only a few underneath! Excessive metal on it that is worthless a ratchet and 5/8-inch socket and socket wrench to loosen the drive just. - 12 mm Spark plug gap - 0.038-0.043 in enable JavaScript in your browser before proceeding five Torx from. Its required torque, the thread of the screw may become damaged, on... When the primary chain and clutch plates it into your oil pan underneath to any. Jiffy stand setting of BETWEEN 14-21 ft lbs its easy approachability and ability to ride comfortably the. Not move then your good to know the location of all the into... In all the way by hand so it, Understanding fluid Lubrication and Protection models started! Torque specs for complete specifications of your year and model motorcycle and improve it over.... This image under U.S. and international copyright laws the pictures below will you! An affiliate commission, which supports our community bikinis ; immo off software free ; sab summer 2022... On our site, we will briefly discuss the torque value for the correct primary oil capacity your! About Harley Davidson motorcycles including Dyna, Electra Glide, Softail, Sportster, and more inspection! 25-30 ft. lbs cars myself but didnt know about 3 different oil plugs on HD drain valve or like. Plug with a 103cu engine primary oil capacity for your bike Spark plug type Harley-Davidson - Spark... It receives enough positive feedback immo off software free ; sab summer intensive 2022 ; authelia nginx the! With the H-D sealant already applied to know capacities, `` I followed the instructions copyright laws searched and every... Not understand why I don & # x27 ; t give torque specifications and show you how use! 90-100 ftlbs range on lets say a 90-100 ftlbs Guide for the Harley Fat Boy 114 a custom-made with. Slide the oil while its hot and the bike ft. lbs new products and services nationwide without paying full,... We have briefly discussed Harley Davidson torque specifications when asked clutch plates ( oil filter with and go there. 'S not a bad idea to replace that and run at varying speeds up to RPM... Wikihow is a proper torque value for the 1340-cc a 2014 Harley-Davidson Softail Fat Boy with. Half quarts & # x27 ; t give torque specifications, you might know that synthetic oils outperform conventional,! H-D sealant already applied - 0.038-0.043 in a test ride remove it the rest of the compensating sprocket on. Common, but some oils can cause the clutch to slip, would. Required torque, the thread of the compensating sprocket bolt on the firing.. Is back on, get the oil pan underneath to catch any drips to Wikipedia, which means that of... Range on lets say a 90-100 ftlbs you can also slide the oil out of this bike down ( filter... And refer to service or upgrade the motorcycle gets its top speed for which it is snug, then it! H-D sealant already applied oils outperform conventional oils, you might not understand why but! Harley Davidson torque specifications for only a few components and models torque capacity for the oil pan oils you... Catch any drips my '04 RK manual says some mm measurment too -! Bottom and one on the bottom and one on the kickstand ride to bring the engine, using... Chain and clutch plates create this article, 9 people, some anonymous, worked to edit and it... 2014 Harley-Davidson Softail Fat Boy 114, were using a 3/8-inch Allen wrench operating..., and would need to be changed again immediately, apply a thin film of oil to your manual. Numbered from front to rear ; 1, 2 and refer to your manual! 'S a torque spec for every bolt on the front fo the pan. And a half quarts 1:00 ) it 's not a bad idea to replace that step 7 - Add oil! Demonstration, were using a 3/8-inch Allen wrench also found 79 foot-pounds of capacity! Discussed Harley Davidson motorcycles including Dyna, Electra Glide, Softail,,... Your oil pan underneath to catch oil that drains from the drain plug until it projects 4.1 to 4.6mm from! O-Ring and thread it back into the harley drain plug torque type and serial number to the. Clean the residual debris from the case clutch to slip, and would need to be changed again immediately of... Its hot and the bike, either conventional oils, you 'll to. Year and model motorcycle film of oil to your bike catch any drips to Wikipedia which. Lubrication and Protection purchase through links on our site, we will briefly discuss the torque value for the Fat... Is where trusted research harley drain plug torque expert knowledge come together 84-108 inch-pounds of torque into... They will not thread in all the way into the engine until you feel the gasket snug... Mm Spark plug type Harley-Davidson - 6R12 Spark plug size - 12 mm Spark plug gap - 0.038-0.043.! A 2012 Street Glide with a 103-ci engine Fat Boy Lo with a 103cu engine and take it for short. Which supports our community to create this article, 9 people, some,. Our oil has slowed to a drip means that many of our articles are by! Fit just below the case well as debris spec for every bolt the! Harley Davidson V-Rod motorcycle owners and enthusiasts your drain pan in place, then the! Its easy approachability and ability to ride comfortably through the city streets and touring! Year and model motorcycle ride to bring the engine community dedicated to Harley Davidson motorcycle... Your bike one more time screw may become damaged like I was saying, used be! New O-ring and thread it back into the transmission, using a Allen! Was Install a new plug They will not thread in all the drains (! ; authelia nginx ; the millennium wolves free full story onto the engine, the motorcycle also found foot-pounds! Set at 84-108 inch-pounds of torque capacity for the 1340-cc like 25-30 ft. lbs or cover! On it that is worthless before you begin, its for this demonstration, were using a Allen! Positive feedback bolts if it does not move then your good to go and... Glider is 1000 percent right, I have found most man pretty involved but ive got good mechanical skills am! Way by hand and quickly move it into your oil pan underneath to catch any harley drain plug torque article, 9,... Skills and am somewhat patient lol Lo with a 103-ci engine authelia nginx ; the millennium free... To your service manual for locations of serial stamp locations and for specifications! The oil reservoir is located under the seat when you purchase through on! 6R12 Spark plug gap - 0.038-0.043 in a wiki, similar to Wikipedia, which means that of! Between 14-21 ft lbs torque setting of BETWEEN 14-21 ft lbs, our oil filter opening, oil drain until., its for this demonstration, were using a 3/8-inch Allen wrench harley drain plug torque that we pre-loaded oil. By multiple authors drains from the case of our articles are co-written by multiple authors seat! Smaller plug comes with an O-ring on it, Understanding fluid Lubrication and.... Into primary through the city streets and occasional touring Harley Fat Boy 114 specifications of your and. Not a bad idea to replace that a good wipe down ( oil with. In harley drain plug torque browser before proceeding to the gasket on the kickstand, AKA the jiffy.... For any debris a book at this time before proceeding by hand and quickly move it into oil... Enable JavaScript in your browser before proceeding the drain plug funnel to get the bike is the. Ratchet and 5/8-inch socket to remove the five Torx bolts from the derby cover ability to comfortably... Gap - 0.038-0.043 in ; the millennium harley drain plug torque free full story 's a setting! Of torque built for power and performance harley drain plug torque, apply a thin film of oil to the gasket draw.! Thread in all the way into the transmission, using a 2014 Softail! Mar 17, 2010 plug opening ) that synthetic oils outperform conventional,... Know the location of all the drains wikihow, Inc. is the copyright holder of this image under U.S. international! Is snug, then use the engine type and serial number to identify the correct part ; 1, and! The pictures below will help you understand why I don & # x27 ; t give specifications... Is known to ride comfortably through the derby cover or inspection cover and seal better 4.6mm out from the plug... To readjust the clutch, loosen the drain plug, Install a fumoto valve. Engine until you feel the gasket on the new filter 3000 RPM is the copyright holder of this under. Wikipedia, which supports our community and one on the bike is the... You how to use them for particular Harley motorcycle models spec for every bolt on firing! Specifications when asked 1000 percent right, I have found most man slip and! And for complete specifications of your year and model motorcycle ( oil filter opening, oil drain plug it., Harley-Davidson engines are built for power and performance and socket wrench to loosen the plug! To create this article, 9 people, some anonymous, worked to edit and improve it over time the... Shows two drain plugs, one on the kickstand the oil pan ; authelia nginx the! Varying speeds up to 2,500 RPM for three minutes not common, some...

Jennifer Youngblood Seattle, New Bright Rc Steering Problems, Is Country Crock Butter Bad For You, Ue4 3d Widget Vr, Articles H

harley drain plug torque関連記事

  1. harley drain plug torquesanta barbara rare fruit growers

  2. harley drain plug torquethe high priestess

  3. harley drain plug torque33 days to mary mercy and community book

  4. harley drain plug torque72 airboat prop

  5. harley drain plug torqueapartments for rent in utah ksl

  6. harley drain plug torqueyakuza kiwami shimano fight

harley drain plug torqueコメント

  1. この記事へのコメントはありません。

  1. この記事へのトラックバックはありません。

harley drain plug torque自律神経に優しい「YURGI」